View Single Post
  #5  
Old 01-05-2022, 08:42 PM
StephenVA StephenVA is offline
Member
 
Join Date: Jun 2013
Location: Virigina, USA
Posts: 2,573
StephenVA is on a distinguished road
BMW Vehicle Parasitic Draw Testing
When your car battery goes dead overnight, usually either the battery is at the end of its life span, or you left something on, such as a light. Occasionally something is drawing power that's not of your doing. This is a parasitic draw, and it can cause the same result as leaving the headlights on: a dead battery in the morning.

1. Remove the negative side battery cable from the negative battery terminal.
2. Connect the black wire to the com input on the multimeter and the red wire to the 10A or 20A input on the multimeter. The meter needs to be able to read at least a 2 or 3 amps for this test to work. Connecting the red wire to the mA input on the multimeter won't work and could damage the meter.
3. Attach a multimeter (set the dial on the multimeter to measure Amps as per multimeter’s instructions) between the negative cable and the negative battery post. Wait a few seconds to several minutes for the car to go into sleep mode - i.e. when you make the contact with the ammeter, the cars computer systems "wake up". After a bit of time they will go back to "sleep".
4. If the ammeter is reading over 25-50 milliamps, something is using too much battery power.
5. Go to the fuse panel(s) and remove fuses, one at a time. Pull the main fuses (higher amp ratings) last. Perform the same steps for relays found in the fuse panel. Sometimes relay contacts can fail to release causing a drain. Be sure to observe the ammeter after pulling each fuse or relay.
6. Watch for the ammeter to drop to acceptable drain. The fuse that reduces the drain is the draw. Consult the owners' manual or service manual to find what circuits are on that fuse.
7. Check each device (circuit) on that fuse. Stop each lamp, heater, etc. to find the drain.
8. Repeat steps 1 & 2 to test your repair. The ammeter will tell you the exact numbers.


BMW Battery Draw Testing
If your Shifter light is on, the car is definitely staying awake.
Your Battery will go down within days. If the light is not on you can have a parasitic draw, while the car is in sleep mode. The only difference, is the second draw is from a module which can’t wake the system (not mission critical), and it will take a lot longer to discharge the battery.
Shifter light NOT on: (battery fully charged)
Find the ground cable on the battery, but do not disconnect. (the cable end connected to the body not the battery, is easier to handle.)
Connect the Positive lead from the “Fluke” to the body of the car (good ground)
Connect the Negative lead to the (brown) ground cable (you can puncture it)
Make sure it’s easy to disconnect the (brown) cable from the body, but don’t take it off yet.
Open the glove box and remove and disable the switch so the light will not turn on, locate the fuse box.
Start the car and run at idle, turn EVERYTHING on, and activate all the components (sunroof, windows, a/c, lights …..) run 5 min.
turn the car off and remove the key. Open all doors and trunk, and with a screw driver,
close the door locks so the system thinks all doors and the trunk is closed.
Now lock the vehicle with the remote.
The “Fluke” must be set up to “A” not “mA” otherwise you will blow the
fuse in the meter. Remove the nut from the ground cable and remove the cable from the stud. You meter will indicate around (300mA).
Let the car go to sleep. (16 min) minimum, if this is not happening start over.
After the sleep mode is on the draw should not be more then 50mA, if it’s more go to the glove box and start pulling fuses one by one and check the draw after each one, but do NOT re-install the fuse. Pull the fuse and leave it out
There are some fuses under the right cover in the trunk. If you pull a fuse and car wakes up start over (next time ignore this fuse). If you pull a fuse and the draw drops to around 50mA, read the label on the fuse, you will know which circuit is faulty.
Relay locked on - test
Take out your infrared temp gun and measure each relay. The one that is hotter is "on". Simple!
Attached Images
   
Attached Images
File Type: pdf HowtodoParasiticdraintestacrossfuses.pdf (69.8 KB, 59 views)
__________________

2005 X5 4.8IS
The Blue ones are always FASTER....

Current Garage:
2005 X5 4.8is
2002 M5 TiSilver
2003 525iT
1998 528i
Former Garage Stable Highlights
2004 325XiT Sport
1973 De Tomaso Pantera, L Model
1970 Dodge Challenger T/A 4 sp Alpine White
1970 Dodge Challenger T/A 4 sp GoManGo Green
1971 Dart Sport, “Dart Light” package
1969 Road Runner 383
1968 Ply Barracuda 340S FB Sea-foam Green
Reply With Quote

Sponsored Links